Single Pane Glass Repair in an Aluminum Frame, Part 2

This week we are going to continue our series on single pane window glass repair. Let's talk about broken glass in a fixed window, usually referred to as a picture window. The most common type will have metal stops on the outside, around all four edges of the window glass. Sometimes these stops will be held in place with screws, and other times there will be aluminum stops that snap in place. In some rare instances there will be a rubber material in place of metal. If you have the screw type, you remove all of the screws and each piece will come out. If you have the metal snap in stops, carefully pry the stop from the frame using a small, flat screwdriver or a putty knife. You want to start in a corner and work along the stop until it comes out. Don't pry too much because the stops can bend very easily. If you have the rubber type, pry a corner away using the screwdriver, grab it with your fingers, and pull out the rubber. The glass shouldn't fall out because there is a glue or tape on the edge, holding the glass in place.

From here, You can get your measurements for the new piece of glass. The glass edges will be exposed, and you can hook your tape measure to the edge and get your width and height. If there is a hole in the glass, measure the glass thickness. If there isn't a hole, put on some gloves and carefully push on the glass where the crack is located. This will expose the edge so you can measure it. When you go to get the new glass, you're going to need a tube of silicone to replace the glue or tape holding the glass in place. Once you get the glass home, you need to remove the old glass. Go inside and cut between the glass and frame using a utility knife with a new blade. This will cut away the silicone or tape that is holding the old glass. Be sure to wear heavy gloves during this process to avoid getting cut. Start at the top and cut across from one corner to the other. Then cut down one side, from top to bottom. Do the other side the same way. At this point the glass should fall out. You should place a tarp or sheet under the window to catch the glass as it falls out. Using a stiff putty knife, scrape off the old silicone or tape from the frame. If there were setting blocks on the bottom, be sure to reuse them. They act as shims to raise the glass off the bottom.

Now run a bead of silicone about 3/16" thick around the perimeter of the opening. Grab your new glass on the sides, angle the bottom in and the top out, set the glass on the setting blocks, then slowly raise the glass up into place. Push just hard enough that all four edges of the glass contact the silicone, but not so hard that the glass makes contact with the metal frame. Install your outside stops. Don't clean the glass for 24 hours so the silicone can set up.

Next week I will continue this series on window glass repair.

John Rocco has been installing replacement windows since 1978. To learn more, visit How To Install Windows

---

Conservatory Planning Permission in the UK

It is quite unusual in the UK for a new... Read More

How to Select Exterior Shutters

Installing exterior shutters is a relatively quick way to add... Read More

Gas Stoves - Pros and Cons

Gas stoves are those preferred by professionals. The heat distribution... Read More

Does Your Home Need Concrete Waterproofing?

Many areas of your home can benefit from concrete waterproofing.... Read More

Colour Your World With Art

When you buy art, you may think you not consciously... Read More

Asphalt Paving Driveway Maintenance Tips

Asphalt paving or Hot Mix Asphalt is typically what one... Read More

Acting As Your Own General Contractor When Building Your Dream Home

This article is intended for the DIY (Do It Yourself)... Read More

Materials For Building Window Shutters

Shopping for window shutters can become confusing because of the... Read More

Reduce Your Heating Bills This Winter - Overlooked Sources of Heat Loss in the Home

Imagine leaving a window open all winter long ? the... Read More

Planning Permission Tips Uk - How To Select A Property to Extend or Develop

Many people purchasing a property for their main home actually... Read More

Building or Decorating Your Home Requires House Plans

There are some things to consider when creating plans for... Read More

Selecting Color Schemes

Choosing a color scheme for a room can be a... Read More

Buying The Right Bed Sheets For Your Bed

You spend a lot of your life in your bed... Read More

If You Think Mold and Mildew Hibernate During The Winter, Think Again!

If You Think Mold and Mildew Hibernate During The Winter,... Read More

This Is Why People Should Consider Granite Countertops

Granite countertops are among the most beautiful things you can... Read More

?5 Fast Ideas to Freshen the Look of your Room

"Company's coming and my place doesn't look right?"You know how... Read More

Hidden Causes of Water Damage in the Home

In addition to causing destruction, water damage also has an... Read More

Inspecting your Swimming Pool

With the varied availability of swimming pool equipment and designs,... Read More

Flooring: Installing Ceramic Tile

Ceramic Tile brings a texture, richness and color to a... Read More

How To Identify A Quality Interior Shutter

1. Shutters have proper louver tensionThe shutters louvers should be... Read More

Color Help: Choosing Color Combinations

Choosing a color scheme can be a nerve-wracking business. For... Read More

Kitchen Remodel - How to Survive

You have decided to make the plunge and begin to... Read More

The $27,000 Toilet Seat - Funny DIY Story

This story was told to me by a plumber I... Read More

Discovering Fiberglass Roofing Panels for Your Roofing Needs

Roofs are an integral part of the house. The design... Read More

Home Sweet Home

All of us live in houses but how many of... Read More